M202 FLASH

The United States Army issued M202s as needed, with each rifle company's headquarters being authorized a single launcher, generally issued as one per rifle platoon. While vastly more lightweight than the M2 flamethrower it replaced, the weapon was still bulky to use and the ammunition suffered from reliability problems. As a result, the weapon had mostly been relegated to storage by the mid-1980s, even though it nominally remains a part of the U.S. Army arsenal. In USMC service, the M202 was issued to dedicated teams of 0351 Assaultman at the battalion level. The Weapons Platoon's assault section contained three squads, each with a launcher team. With the introduction of the SMAW in the mid 1980s, the M202 was phased out and replaced by SMAW launchers. The M202A1 has been among weapons listed on the inventory of U.S. units in the War in Afghanistan.

The M202A1 features four tubes that can load 66 mm incendiary rockets. The M74 rockets are equipped with M235 warheads, containing approximately 1.34 pounds (610 g) of an incendiary thickened pyrophoric agent (TPA). TPA is triethylaluminum (TEA) thickened with polyisobutylene, in the presence of n-hexane, preventing spontaneous combustion after the warhead rupture. TEA, an organometallic compound, is pyrophoric and burns spontaneously at temperatures of 1600 °C (2912 °F) when exposed to air. It burns "white hot" because of the aluminum, much hotter than gasoline or napalm. The light and heat emission is very intense and can produce skin burns from some (close) distance without direct contact with the flame, by thermal radiation alone. The XM96 was an M74-derived riot control round containing CS gas. This was trialed beginning around 1968, but never entered service.

The weapon is meant to be fired from the right shoulder, and can be fired from either a standing, crouching, or prone position. It is loaded with a clip which holds a set of four rockets together, which is inserted into the rear of the launcher and can be pushed past the launching position to enable the launcher to be carried while loaded more easily. The M202A1 was rated as having a 50% chance of hit against the following targets at the noted ranges, assuming all four rockets were fired at the same time: Bunker aperture: 50 meters Window: 125 meters Weapons position or stationary vehicle: 200 meters Squad-sized troop formation: 500 meters

United States United States Army and US Marine Corps Vietnam PAVN Chemical Corps