flamethrower

Gases are safer in peacetime applications because their flames have less mass flow rate and dissipate faster and often are easier to extinguish. Apart from the military applications, flamethrowers have peacetime applications where there is a need for controlled burning, such as in sugarcane harvesting and other land-management tasks. Various forms are designed for an operator to carry, while others are mounted on vehicles.

• Illustration — German Brandkommando (burning detachment) destroying Warsaw during the planned destruction of the city Modern flamethrowers were first used during the trench warfare conditions of World War I and their use greatly increased in World War II. They can be vehicle-mounted, as on a tank, or man-portable. The man-portable flamethrower consists of two elements—the backpack and the gun. The backpack element usually consists of two or three cylinders. In a two-cylinder system, one cylinder holds compressed, inert propellant gas (usually nitrogen), and the other holds flammable liquid, typically some form of petrochemical. A three-cylinder system often has two outer cylinders of flammable liquid and a central cylinder of propellant gas to maintain the balance of the soldier carrying it. The gas propels the liquid fuel out of the cylinder through a flexible pipe and then into the gun element of the flamethrower system. The gun consists of a small reservoir, a spring-loaded valve, and an ignition system; depressing a trigger opens the valve, allowing pressurized flammable liquid to flow and pass over the igniter and out of the gun nozzle. The igniter can be one of several ignition systems: A simple type is an electrically heated wire coil; another used a small pilot flame, fueled with pressurized gas from the system. Flamethrowers were primarily used against battlefield fortifications, bunkers, and other protected emplacements. A flamethrower projects a stream of flammable liquid, rather than flame, which allows bouncing the stream off walls and ceilings to project the fire into unseen spaces, such as inside bunkers or pillboxes. Typically, popular visual media depict the flamethrower as short-ranged and only effective for a few metres (due to the common use of propane gas as the fuel in flamethrowers in movies, for the safety of the actors). Contemporary flamethrowers can incinerate a target some 50 – from the operator; moreover, an unignited stream of flammable liquid can be fired and afterwards ignited, possibly by a lamp or other flame inside the bunker. Flamethrowers pose many risks to the operator. The first disadvantage is the weapon's weight and length, which impairs the soldier's mobility. The weapon is limited to only a few seconds of burn time, since it uses fuel very quickly, requiring the operator to be precise and conservative. Flamethrowers using a fougasse-style explosive propellant system also have a limited number of shots. The weapon is very visible on the battlefield, which causes operators to become immediately singled out as prominent targets, especially for snipers and designated marksmen. Flamethrower operators were rarely taken prisoner, especially when their target survived an attack by the weapon; captured flamethrower users were in some cases summarily executed. The flamethrower's effective range is short in comparison with that of other battlefield weapons of similar size. To be effective, flamethrower soldiers must approach their target, risking exposure to enemy fire. Vehicular flamethrowers also have this problem; they may have considerably greater range than a man-portable flamethrower, but their range is still short compared with that of alternative weapons. • Illustration — Army War Show November 27, 1942 The risk of a flamethrower operator being caught in the explosion of their weapon due to enemy hits on the tanks is exaggerated in films. In some cases, the pressure tanks have exploded and killed the operator when hit by bullets or grenade shrapnel. In the documentary Vietnam in HD, platoon sergeant Charles Brown tells of how one of his men was killed when his flamethrower was hit by grenade shrapnel during the battle for Hill 875. The pressurizer is filled with a non-flammable gas that is under high pressure. If this tank ruptures, it might knock the operator forward as it was expended in the same way a pressurized aerosol can bursts outward when punctured. The fuel mixture in the containers is difficult to light, which is why magnesium-filled igniters are required when the weapon is fired. When pierced by a bullet, a metal can filled with diesel or napalm will merely leak unless the round is an incendiary type that may ignite the mixture inside. The best way to minimize the disadvantages of flame weapons was to mount them on armoured vehicles. The Commonwealth and the United States were the most prolific users of vehicle-mounted flame weapons; the British and Canadians fielded "Wasps" (Universal Carriers fitted with flamethrowers) at infantry battalion level, beginning in mid-1944, and eventually incorporating them into infantry battalions. Early tank-mounted flamethrower vehicles included the "Badger" (a converted Ram tank) and the "Oke", used first at Dieppe.

In a propane-operated flamethrower, the gas is expelled through the gun assembly by its own pressure and is ignited at the exit of the barrel through piezo ignition. Liquid-operated flamethrowers use a smaller tank with a pressurized gas to expel the flammable liquid fuel. The propellant gas is fed to two tubes. The first opens in the fuel tanks providing the pressure necessary for expelling the liquid. The other tube leads to an ignition chamber behind the exit of the gun assembly, where it is mixed with air and ignited through piezo ignition. This pre-ignition line is the source of the flame seen in front of the gun assembly in movies and documentaries. As the fuel passes through the flame, it is ignited and propelled towards the target.

• Illustration — Boeotian flame thrower (model), Thessaloniki Science Center and Technology Museum The concept of projecting fire as a weapon has existed since ancient times. During the Peloponnesian War, Boeotians used some kind of a flamethrower trying to destroy the fortification walls of the Athenians during the Battle of Delium. According to Polybius the ancient Rhodian admiral Pausistratus used a device called πυρφόρος (pyrphoros; "fire-bearer") designed to project fire onto enemy ships while keeping it safely distant from the user's own vessel. The apparatus consisted of a funnel-shaped container (scoop or basket) filled with combustible material, suspended from the end of a pole by an iron chain that projected from the prow. These poles were supported by ropes running along the inner sides of the hull, allowing the funnel to extend outward on either side of the bow. Because the funnel was angled away from the ship, fire could be discharged into an enemy vessel during a charge or while passing alongside, without risking accidental ignition of the user's own ship.

In 107 AD the Romans used a flamethrower against the Dacians; the device was similar to the one used at Delium. Later, during the Byzantine era, sailors used rudimentary hand-pumped flamethrowers on board their naval ships. Greek fire, extensively used by the Byzantine Empire, is said to have been invented by Kallinikos of Heliopolis, probably about 673 AD. Byzantine texts described weapons, used by Byzantine land forces, which were shooting Greek fire and called cheirosiphona (χειροσίφωνα, meaning hand-held siphons, singular χειροσίφωνο). The flamethrower found its origins in a device consisting of a hand-held pump that shot bursts of Greek fire via a siphon-hose and a piston which ignited it with a match, similar to modern versions, as it was ejected. An illustration in Poliorcetica of Hero of Byzantium display a soldier with a portable flamethrower. Byzantines also used ceramic hand grenades filled with Greek fire. Greek fire, used primarily at sea, gave the Byzantines a substantial military advantage against enemies such as members of the Arab Empire (who later adopted the use of Greek fire). An 11th-century illustration of its use survives in the John Skylitzes manuscript.

• Illustration — A Chinese flamethrower from the Wujing Zongyao manuscript of 1044 AD, Song dynasty The Pen Huo Qi ("fire spraying device") was a Chinese piston flamethrower that used a substance similar to petrol or naphtha, invented around 919 AD during the Five Dynasties and Ten Kingdoms period. The earliest reference to Greek fire in China was made in 917, written by Wu Renchen in his Spring and Autumn Annals of the Ten Kingdoms. In 919, the siphon projector-pump was used to spread the 'fierce fire oil' that could not be doused with water, as recorded by Lin Yu (林禹) in his Wu-Yue Beishi (吳越備史), hence the first credible Chinese reference to the flamethrower employing the chemical solution of Greek fire. Lin Yu mentioned also that the 'fierce fire oil' derived ultimately from China's contact in the 'southern seas', with Arabia (大食國 Dashiguo). In the Battle of Langshan Jiang (Wolf Mountain River) in 919, the naval fleet of the Wenmu King of Wuyue defeated the fleet of the Kingdom of Wu because he had used 'fire oil' to burn his fleet; this signified the first Chinese use of gunpowder in warfare, since a slow-burning match fuse was required to ignite the flames. The Chinese applied the use of double-piston bellows to pump petrol out of a single cylinder (with an upstroke and a downstroke), lit at the end by a slow-burning gunpowder match to fire a continuous stream of flame (as referred to in the Wujing Zongyao manuscript of 1044). In the suppression of the Southern Tang state by 976 AD, early Song naval forces confronted them on the Yangtze River in 975. Southern Tang forces attempted to use flamethrowers against the Song navy, but were accidentally consumed by their own fire when violent winds swept in their direction. Documented also in later Chinese publications, illustrations and descriptions of mobile flamethrowers on four-wheel push carts appear in the Wujing Zongyao, written in 1044 (its illustration redrawn in 1601 as well). Advances in military technology aided the Song dynasty in its defense against hostile neighbours to the north, including the Mongols.

Abū ʿAbdallāh al-Khwārazmī in Mafātīḥ al-ʿUlūm (“Keys to the Sciences”) ca. 976 AD mentions the bāb al-midfa and the bāb al-mustaq which he said were parts of naphtha-throwers and projectors (al-naffātāt wa al-zarāqāt). Book of Ingenious Mechanical Device (Kitāb fī ma 'rifat al-ḥiyal al-handasiyya) of 1206 by Ibn al-Razzaz al-Jazari mentioned about ejectors of naphtha (zarāqāt al-naft).

During the Great Siege of Malta the defenders used a type of flamethrower known as Trump, consisting of a tube loaded with sulphur resin and linseed oil. It produced a flame that was several yards long

The book Hồ trường khu cơ by Dao Duy Tu describes a flamethrowing weapon called the fire tiger "The fire-thrower is also called fire-tiger, has a large bulb about one meter long, when in battle it shoots fire, the tube shoots out pine resin, if it hits something, it immediately catches fire...". "Because the fire burns fiercely, it is called fire-tiger". These weapons were later used by the Tay Son Army.

In 1702, the Prussian Army tested P. Lange's "hose-fire-spray (Schlangen-Brand-Spritze) who produced a jet of fire 12 ft wide and long; two years later it was rejected as useless. Peter the Great's chief engineer Vasily Dmitrievich Korchmin designed various incendiary weapons, such as incendiary rockets and furnaces for heating cannonball; two Russian ships the “Svyatoy Yakov” and “Landsou” were armed with flamethrower tubes designed by him. He also developed instructions for their use together with the Tsar. In the 1750s a French engineer named Dupre, developed a new flammable mixture; it was tested in LeHavre and set fire to a sloop. During the British shelling of LeHavre in 1759, the French War Minister tried to obtain authorization to use this fuel.

In 1814, American inventor Uriah Brown built a steam-powered flamethrower and performed a public demonstration for a "vast concourse" of citizens. Although flamethrowers were never used in the American Civil War, "Greek Fire" shells were produced and used by Union troops during the Second Battle of Charleston Harbor. During the 1871 siege of Paris, French chemist Marcellin Berthelot suggested pumping flaming petroleum at Prussian troops. In 1898 Russian captain Sigern-Korn experimented with burning jets of kerosene for defensive use; in theory, they would be fired from parapets of fortifications. The idea was abandoned due to technical issues.

• Illustration — French soldiers using flamethrowers in World War I, 1917 During the siege of Port Arthur, Japanese combat engineers used hand pumps to spray kerosene into Russian trenches. Once the Russians were covered with the flammable liquid, the Japanese would throw bundles of burning rags at them. Before WWI, German pioneers used the Brandröhre M.95 a weapon consisting of a sheet metal tube (wide and long) filled with an incendiary mixture, and a friction igniter activated by a lanyard. The Brandröhre was designed to be used against enemy casemates; a long pole was used to reach the target and the lanyard was pulled to ignite the fuel; producing a 2 m long stream of fire. Those weapons were deployed in six-man teams and were limited by their short range. In theory the Brandröhre was replaced by the flamethrower in 1909 but it was still in use in WWI; it was used during the assaults on Fort du Camp-des-Romains in 1914 and Fort Vaux in 1916. Bernhard Reddeman, a German military officer and former fireman, converted steam powered fire engines into flamethrowers; his design was demonstrated in 1907. The English word flamethrower is a loan-translation of the German word Flammenwerfer, since the modern flamethrower was invented in Germany. The first flamethrower, in the modern sense, is usually credited to Richard Fiedler. He submitted evaluation models of his Flammenwerfer to the German Army in 1901. The most significant model submitted was a portable device, consisting of a vertical single cylinder 4 ft long, horizontally divided in two, with pressurized gas in the lower section and flammable oil in the upper section. On depressing a lever the propellant gas forced the flammable oil into and through a rubber tube and over a simple igniting wick device in a steel nozzle. The weapon projected a jet of fire and enormous clouds of smoke some 20 yd. It was a single-shot weapon—for burst firing, a new igniter section was attached each time. In 1905 Fiedler's flamethrower was demonstrated to the Prussian Committee of Engineers. In 1908 Fiedler started working with Reddeman and made some adjustments to the design; an experimental pioneer company was created to further test the weapon. • Illustration — German flamethrowers during the First World War on the Western Front, 1917 It was not until 1911 that the German Army accepted their first real flamethrowing device, creating a specialist regiment of twelve companies equipped with Flammenwerfer Apparent. Despite this, use of fire in a World War I battle predated flamethrower use, with a petrol spray being ignited by an incendiary bomb in the Argonne-Meuse sector in October 1914. The flamethrower was first used in World War I on 26 February 1915 when it was briefly used against the French outside Verdun. On 30 July 1915 it was first used in a concerted action, against British trenches at Hooge, where the lines were 4.5 m apart—even there, the casualties were caused mainly by soldiers being flushed into the open and then shot rather than from the fire itself. After two days of fighting the British had suffered casualties of 31 officers and 751 other ranks. • Illustration — Belgian soldier wounded by a flamethrower (World War I) The success of the attack prompted the German Army to adopt the device on all fronts. Flamethrowers were used in squads of six during battles, at the start of an attack destroying the enemy and to the preceding the infantry advance. The flamethrower was useful at short distances but had other limitations: it was cumbersome and difficult to operate and could only be safely fired from a trench, which limited its use to areas where the opposing trenches were less than the maximum range of the weapon, namely 18 m apart—which was not a common situation; the fuel would also only last for about a minute of continuous firing. The Germans deployed flamethrowers during the war in more than 650 attacks. The Ottoman Empire received 30 flamethrowers from Germany during the war. German flamethrowers were also used by Bulgarian forces. Austria-Hungary adopted German designs; but also developed its own flamethrowers in 1915. These included the 50 l M.15 Flammenwerfer, which required a crew of three men and was too unwieldy for offensive use; a defensive 200 l model and a more portable 22 l model were also produced. Austro-Hungarian flamethrowers were unreliable and long hoses were used to prevent the shooter from igniting the fuel tank The British experimented with flamethrowers in the Battle of the Somme, during which they used experimental weapons called "Livens Large Gallery Flame Projectors", named for their inventor, William Howard Livens, a Royal Engineers officer. This weapon was enormous and completely non-portable. The weapon had an effective range of 90 yd, which proved effective at clearing trenches, but with no other benefit the project was abandoned. Two Morriss static flamethrowers were mounted in HMS Vindictive and several Hay portable flamethrowers were deployed by the Royal Navy during the Zeebrugge Raid on 23 April 1918. A British newspaper report of the action referred to the British flamethrowers only as flammenwerfer, using the German word. The French Army deployed the Schilt family of flamethrowers, which were also used by the Italian Army. In 1931 the São Paulo Public Force created an assault car section. The first vehicle to be incorporated was a tank built from a Caterpillar Twenty Two tractor, featuring a turret mounted flamethrower and four Hotchkiss machineguns on the hull. It was used in combat during the Constitutionalist Revolution, routing federal troop from a bridge in an engagement in Cruzeiro.

In the interwar period, at least four flamethrowers were used in the Chaco War by the Bolivian Army, during the unsuccessful assault on the Paraguayan stronghold of Nanawa in 1933. During the battle of Kilometer 7 to Saavedra, Major Walther Kohn rode in a flamethrower equipped tankette; due to heat he exited the tank to fight on foot and was killed in combat.

The flamethrower was used extensively during World War II. In 1939, the German military first deployed man-portable flamethrowers against the Polish Post Office in Danzig. Subsequently, in 1942, the U.S. Army introduced its own man-portable flamethrower. The vulnerability of infantry carrying backpack flamethrowers and the weapon's short range led to experiments with tank-mounted flamethrowers (flame tanks), which were used by many countries.

• Illustration — A German soldier operating a flamethrower in 1944 • Illustration — A German soldier using a flamethrower in Russia The Germans made considerable use of the weapon (Flammenwerfer 35) during their invasion of the Netherlands and France, against fixed fortifications. World War II German army flamethrowers tended to have one large fuel tank with the pressurizer tank fastened to its back or side. Some German army flamethrowers occupied only the lower part of its wearer's back, leaving the upper part of his back free for an ordinary rucksack. Flamethrowers soon fell into disfavour. Flamethrowers were extensively used by German units in urban fights in Poland, both in 1943 in the Warsaw Ghetto Uprising and in 1944 in the Warsaw Uprising (see the Stroop Report and the article on the 1943 Warsaw Ghetto Uprising). With the contraction of the Third Reich during the latter half of World War II, a smaller, more compact flamethrower known as the Einstossflammenwerfer 46 was produced. Germany also used flamethrower vehicles, most of them based on the chassis of the Sd.Kfz. 251 half track and the Panzer II and Panzer III tanks, generally known as Flammpanzers. The Germans also produced the Abwehrflammenwerfer 42, a flame-mine or flame fougasse, based on a Soviet version of the weapon. This was essentially a disposable, single use flamethrower that was buried alongside conventional land mines at key defensive points and triggered by either a trip-wire or a command wire. The weapon contained around 8 USgal of fuel, that was discharged within a second, to a second and a half, producing a flame with a 15 yd range. One defensive installation found in Italy included seven of the weapons, carefully concealed and wired to a central control point.

• Illustration — Swedish volunteers in the Finnish Army using a flamethrower in exercises in the Reserve Officer School, 1942. During the Winter War Finland adopted the Italian Lanciafiamme Modello 35 as the Liekinheitin M/40; 176 flamethrowers were ordered but only 28 arrived before the end of the war. Those flamethrowers were not used in the Winter War; but were issued to engineers during the Continuation War along with captured ROKS-2 flamethrowers OT-130 and OT-133 flame tanks were captured from the Soviet Union and issued at the start of the Continuation War; they were considered impratical and later retrofitted with cannons. In 1944 they developed and adopted the Liekinheitin M/44.

Italy employed man-portable flamethrowers and L3 Lf flame tanks during the Second Italo-Abyssinian War of 1935 to 1936, during the Spanish Civil War, and during World War II. The L3 Lf flame tank was a CV-33 or CV-35 tankette with a flamethrower operating from the machine gun mount. In the Northern Africa Theatre, the L3 Lf flame tank found little to no success. An L6 Lf flametank was also developed using the L6/40 light tank platform.

• Illustration — A Japanese soldier firing a Type 93 flamethrower Japan used man-portable flamethrowers to clear fortified positions, in the Battle of Wake Island, Corregidor, Battle of the Tenaru on Guadalcanal and Battle of Milne Bay.

Flamethrowers were also used by the Royal Romanian Army. They were also planned to become self-propelled; the Mareșal tank destroyer was planned to have a command vehicle version armed with machine guns and a flamethrower.

• Illustration — A British World War II–type "lifebuoy" flamethrower in 1944 • Illustration — A Churchill tank fitted with a Crocodile flamethrower in action. • Illustration — An Australian soldier fires a flamethrower at a Japanese bunker The British World War II army flamethrowers, "Ack Packs", had a doughnut-shaped fuel tank with a small spherical pressurizer gas tank in the middle. As a result, some troops nicknamed them "lifebuoys". It was officially known as Flamethrower, Portable, No 2. Extensive plans were made in 1940–1941 by the Petroleum Warfare Department to use flame fougasse static flame projectors in the event of an invasion, with around 50,000 barrel-based incendiary mines being deployed in 7,000 batteries throughout Southern England. The British hardly used their man-portable systems, relying on Churchill Crocodile tanks in the European theatre. These tanks proved very effective against German defensive positions, and caused official Axis protests against their use. This flamethrower could produce a jet of flame exceeding 150 yd. There are documented instances of German units summarily executing any captured British flame-tank crews. In the Pacific theatre, Australian forces used converted Matilda tanks, known as Matilda Frogs.

• Illustration — A soldier from the 33rd Infantry Division uses an M2 flamethrower • Illustration — Soldiers engaging Japanese positions on Okinawa with a flamethrower. • Illustration — An M3A1 from the USMC 2nd Tank Battalion incinerates Japanese pillbox on Saipan. • Illustration — An American flamethrower operator runs under fire • Illustration — Front and rear views of a man with an M2A1-7 United States Army flamethrower In the Pacific theatre, the U.S. Army used M-1 and M-2 flamethrowers to clear stubborn Japanese resistance from prepared defenses, caves, and trenches. Starting in New Guinea, through the closing stages on Guadalcanal and during the approach to and reconquest of the Philippines and then through the Okinawa campaign, the Army deployed hand-held, man-portable units. Often flamethrower teams were made up of combat engineer units, later with troops of the chemical warfare service. The Army fielded flamethrower units, and the Army's Chemical Warfare Service pioneered tank mounted flamethrowers on Sherman tanks (CWS-POA H-4). All the flamethrower tanks on Okinawa belonged to the 713th Provisional Tank Battalion, which was tasked with supporting all U.S. Army infantry. All Pacific mechanized flamethrower units were trained by Seabee specialists with Col. Unmacht's CWS Flamethrower Group in Hawaii. The U.S. Army used flamethrowers in Europe in much smaller numbers, though they were available for special employments. Flamethrowers were deployed during the Normandy landings in order to clear Axis fortifications. Also, most boat teams on Omaha Beach included a two-man flamethrower team. The Army also used the backpack-type M2A1-7 and M2-2 flamethrowers, finding them useful in clearing Japanese trench and bunker complexes. The well known use of the man portable flamethrower was against the formidable defenses at Tarawa in November 1943. The Army pioneered the use of Ronson-equipped M-3 Stuart tanks in the Marianas. These were known as flame tanks. Though effective, they lacked the armour to safely engage fortifications and were phased out in favour of the better-armoured M4 Sherman tanks. Flamethrower Shermans were produced at Schofield Barracks by Seabees attached to the Chemical Warfare Service under Col. Unmacht. CWS designated M4s with "CWS-POA-H" for "Chemical Warfare Service Pacific Ocean Area, Hawaii" plus a flamethrower number. The Army had deployed large flamethrowers mounted on LVT-4 AMTRACs at Peleliu. Late in the war, both services operated LVT-4 and −5 flametanks in limited numbers. The Army still used their infantry-portable systems, despite the arrival of adapted Sherman tanks with the Ronson system (cf. flame tanks). In cases where the Japanese were entrenched in deep caves, the flames often consumed the available oxygen, suffocating the occupants. Many Japanese troops interviewed post war said they were terrified more by flamethrowers than any other American weapon. Flamethrower operators were often the first U.S. troops targeted.

• Illustration — A Finnish soldier with a captured Soviet ROKS-3 flamethrower, June 1943. The flame projector has been designed to resemble a standard infantry rifle. The FOG-1 and −2 flamethrowers were stationary devices used in defense. They could also be categorized as a projecting incendiary mine. The FOG had only one cylinder of fuel, which was compressed using an explosive charge and projected through a nozzle. The November 1944 issue of the US War Department Intelligence Bulletin refers to these "Fougasse flame throwers" being used in the Soviet defense of Stalingrad. The FOG-1 was directly copied by the Germans as the Abwehrflammenwerfer 42. Unlike the flamethrowers of the other powers during World War II, the Soviets were the only ones to consciously attempt to camouflage their infantry flamethrowers. With the ROKS-2 flamethrower this was done by disguising the flame projector as a standard-issue rifle, such as the Mosin–Nagant, and the fuel tanks as a standard infantryman's rucksack. This was to try to stop the flamethrower operator from being specifically targeted by enemy fire. This "rifle" had a working action which was used to cycle blank igniter cartridges.

• Illustration — A riverboat of the U.S. Brownwater Navy shooting ignited napalm from its mounted flamethrower during the Vietnam war • Illustration — An M67 "Zippo" tank of the USMC during the Vietnam War The United States Marines used flamethrowers in the Korean and Vietnam Wars. The M132 armored flamethrower, an M113 armored personnel carrier with a mounted flamethrower, was successfully used in the conflict. Flamethrowers have not been in the U.S. arsenal since 1978, when the Department of Defense unilaterally stopped using them — the last American infantry flamethrower was the Vietnam-era M9-7. They have been deemed of questionable effectiveness in modern combat, though some have made the case for their tactical employment.

Crude homemade flamethrowers were built by Irgun in the late 1940s.

The PLA adopted the Type 74 flamethrower, a copy of the Soviet LPO-50. It was later used in the Sino-Vietnamese War.

LPO-50 and Type 74 flamethrowers were used by NVA forces during the Vietnam War.

The Iraqi army used LPO-50 flamethrowers during the Iran-Iraq War.

Non-flamethrower incendiary weapons remain in modern military arsenals. The U.S. and U.S.S.R. both developed a rocket launcher specifically for the deployment of incendiary munitions, respectively the M202 FLASH and the RPO "Rys" ancestor of the RPO-A Shmel.

As of 2022, the Type 74 was still being used by the Vietnamese Army.

On 22 April 1988, Kanak rebels took 36 French hostages in Ouvéa island, New Caledonia, most of them gendarms and military personnel. On 5 May, after weeks of fruitless negotiations, a team of gendarms and paratroopers from the French Army launched a rescue operation. During the assault, a rebel machine gun position was neutralized using a flamethrower. All hostages were eventually set free.

In 1981, the FBI foiled an attempt by New York-based gun runner George Harrison to smuggle an M2 flamethrower to Ireland for the IRA. In the Troubles, during the mid-1980s, the IRA smuggled in Soviet LPO-50 military flamethrowers (supplied to them by the Libyan government) into Northern Ireland. An IRA team riding on an improvised armoured truck used one of these flamethrowers, among other weapons, to storm a British Army permanent checkpoint in Derryard, near Rosslea, on 13 December 1989.

As of 2003, the locally made Hydroar T1M1 flamethrower was still being used by the 1º Batalhão de Forças Especiais.

As of 2022, the Chinese Army still issues the Type 74 flamethrower. During an operation to hunt down the militant group responsible for the 2015 Aksu colliery attack, after using tear gas and flash grenades to no avail, Chinese paramilitary forces resorted to flamethrowers to root out suspected militants who were hiding in a cave.

• Illustration — Sgt. Joshua Robbins of the 25th Infantry Division using a flamethrower in Iraq, 28 August 2008 Captain Shannon Johnson requested Colonel John A. Toolan to supply his company with flamethrowers during the Second Battle of Fallujah; however no flamethrowers were issued. However, the United States did use various models of flamethrowers throughout the Iraq War in order to clear bushes and reveal hidden IEDs. The People's Mujahedin of Iran claimed flamethrowers were used in the 2013 Camp Ashraf massacre.

As of 2012, the locally made T-148/B flamethrower was still being used by the Italian Army.

Flamethrowers have been used by the Tatmadaw during attacks on Rohingya villages during the Rohingya genocide.

On 8 February 2017, separatist leader Mikhail 'Givi' Tolstykh was killed when an RPO-A Shmel rocket-assisted flamethrower was fired at his office in Donetsk. On 21 November 2022, nine months into the Russian invasion of Ukraine, Russian sources claim that artillery and "heavy flamethrowers" were employed against a Ukrainian concentration of troops near Kupyansk, Kharkiv Oblast. Russian sources use the term "heavy flamethrowers" to describe the TOS-1 multiple thermobaric rocket launchers.

During the Gaza war, footage was published of an Israel Defense Forces (IDF) bulldozer fitted with flame throwers burning down buildings in Gaza. In the 2025 Boulder fire attack, the Egyptian attacker used a makeshift flamethrower to attack a solidarity walk for the hostages taken from Israel.

The use of flamethrowers in war is not generally banned. However, the United Nations Protocol on Incendiary Weapons does forbid the use of incendiary weapons, including flamethrowers, against civilians or against forests unless the terrain is being used to conceal combatants or other military objectives.

In the United States, private ownership of a flamethrower is not restricted by federal law, because a flamethrower is a tool, not a firearm. Flamethrowers are legal in 48 states and restricted in California and Maryland. In California, unlicensed possession of a flame-throwing device—statutorily defined as "any non-stationary and transportable device designed or intended to emit or propel a burning stream of combustible or flammable liquid a distance of at least 10 ft" H&W 12750 (a)—is a misdemeanor punishable with a county jail term not exceeding one year or with a fine not exceeding $10,000 (CA H&W 12761). Licenses to use flamethrowers are issued by the state fire marshal, and they may use any criteria for issuing or not issuing that license which is deemed fit, but must publish those criteria in the California Code of Regulations, Title 11, Section 970 et seq. In the United Kingdom, flamethrowers are "prohibited weapons" under section 5(1)(b) of the Firearms Act 1968 and article 45(1)(f) of the Firearms (Northern Ireland) Order 2004 and possession of a flamethrower would carry a sentence of up to ten years' imprisonment. On 16 June 1994, a man attacked school pupils at Sullivan Upper School, just outside Belfast, with a home-made flamethrower. A South African inventor brought the Blaster car-mounted flamethrower to market in 1998 as a security device to defend against carjackers. It has since been discontinued, with the inventor moving on to pocket-sized self-defence flamethrowers. Elon Musk, CEO of Tesla, Inc. and owner of SpaceX, developed a "not a flamethrower" for public sale through his business, The Boring Company, selling 20,000 units. This device uses liquid propane gas rather than a stream of gasoline, making it more akin to a torch, like those commonly available at home and garden centers.

Flamethrowers are occasionally used for igniting controlled burns for land management and agriculture. For example, in the production of sugar cane, where canebrakes are burned to get rid of the dry dead leaves which clog harvesters, and incidentally kill any lurking venomous snakes. More commonly, a driptorch or a flare (fusee) is used. U.S. troops allegedly used flamethrowers on the streets of Washington, D.C. (mentioned in a December 1998 article in the San Francisco Flier), as one of several clearance methods used for the surprisingly large amount of snow that fell before the presidential inauguration of John F. Kennedy. A history article on the U.S. Army Corps of Engineers notes, "In the end, the task force employed hundreds of dump trucks, front-end loaders, sanders, plows, rotaries, and allegedly flamethrowers to clear the way". Flamethrowers were employed by U.S. combat engineers during the Iraq War; they were used to clear brush and eliminate hiding spots for insurgents. A squad armed with backpack flamethrowers had an important part in the 2012 Summer Paralympics closing ceremony. They had one big tank each. They could make a flame about 12 ft long. In April 2014 it was reported by South Korea's Chosun Ilbo newspaper without confirmation that a North Korean government official, O Sang-Hon, Deputy Minister at the Ministry of Public Security, was executed by flamethrower. In August 2016 it was reported that the Islamic State used flamethrowers to execute six of its commanders in Tal Afar as punishment for their attempt to escape to Syria. It has been known for police to fill a "flamethrower", not with flammable liquid, but rather with tear gas dissolved in water as a riot-control device; see Converted Flamethrower 40.